R www.quadrafire.com7014-082DSeptember 1, 2008CLASSIC BAY 1200 PELLET STOVEO-T LTested and Listed byPortlandOregon USAOMNI-Test Laboratories, Inc.CUSOw
Page 107014-082DSeptember 1, 2008R CB 1200 Pellet Stove Do not terminate vent in any enclosed or semi-enclosed area such as a carport, garage, attic,
R September 1, 20087014-082DPage 11CB 1200 Pellet Stove Improper installation, adjustment, alteration, service or maintenance can cause injury or pro
Page 127014-082DSeptember 1, 2008R CB 1200 Pellet Stove 5Venting SystemsNOTE:• Illustrations reflect typical installations and are FOR DESIGN PURPOSE
R September 1, 20087014-082DPage 13CB 1200 Pellet Stove 12 in.(305mm)MinimumNon-combustible Hearth PadWallThimbleHorizontalTerminationCap2 in.(51mm)M
Page 147014-082DSeptember 1, 2008R CB 1200 Pellet Stove We recommend a minimum of 60 in. (1524mm) vertical, however above the eave is preferred. Both
R September 1, 20087014-082DPage 15CB 1200 Pellet Stove Fire HazardInspection of Chimney:• Masonry chimney must be in good condition.• Meets minimu
Page 167014-082DSeptember 1, 2008R CB 1200 Pellet Stove 6Mobile Home1. An outside air inlet must be provided for the combustion air and must remain
R September 1, 20087014-082DPage 17CB 1200 Pellet Stove 7Appliance Set-UpA. Outside Air Kit Instructions Flex HoseHose ClampCollar AssemblyTrim RingT
Page 187014-082DSeptember 1, 2008R CB 1200 Pellet Stove 3 to 3 inch Top Vent Adapter 3 to 6 inch Top Vent Offset Adapter 1. Put a layer of high te
R September 1, 20087014-082DPage 19CB 1200 Pellet Stove D. Optional Brick Set Installation1. Remove the baffle first, follow instructions on page 33.2
Page 27014-082DSeptember 1, 2008R CB 1200 Pellet Stove and Welcome to the Quadra-Fire Family!Hearth & Home Technologies welcomes you to our tradi
Page 207014-082DSeptember 1, 2008R CB 1200 Pellet Stove G. Optional Gold or Nickel Grille Assembly1. Place the front log in first as shown in Figure
R September 1, 20087014-082DPage 21CB 1200 Pellet Stove 1. A 12 volt AC thermostat is required to operate this pellet appliance. You may use the in
Page 227014-082DSeptember 1, 2008R CB 1200 Pellet Stove 8Operating InstructionsA. Fuel Size And Material1. Wood PelletsFuel pellets are made from sa
R September 1, 20087014-082DPage 23CB 1200 Pellet Stove E. Fire CharacteristicsA properly adjusted fire with the heat output control switch set on “h
Page 247014-082DSeptember 1, 2008R CB 1200 Pellet Stove G. Ignition Cycles1. During each ignition cycle, it is normal to see some smoke in the fireb
R September 1, 20087014-082DPage 25CB 1200 Pellet Stove 9TroubleshootingWith proper installation, operation, and maintenance your appliance will prov
Page 267014-082DSeptember 1, 2008R CB 1200 Pellet Stove Symptom Possible Cause Corrective ActionSlow or smoky start-up (Cont’d)Dirty exhaust and/or v
R September 1, 20087014-082DPage 27CB 1200 Pellet Stove Symptoms Possible Cause Corrective ActionConvection blower fails to start.#1 snap disc defect
Page 287014-082DSeptember 1, 2008R CB 1200 Pellet Stove 10Maintaining & Servicing Your ApplianceC. General Maintenance1. Types of Fuel Dependin
R September 1, 20087014-082DPage 29CB 1200 Pellet Stove 5. Disposal of Ashes• Frequency: As needed• By: HomeownerAshes should be placed in a metal
R September 1, 20087014-082DPage 3CB 1200 Pellet Stove Section 1: Listing and Code Approvals A. Appliance Certifications ...4 B.
Page 307014-082DSeptember 1, 2008R CB 1200 Pellet Stove 7. Cleaning Beneath Heat Exchanger • Frequency: Monthly or after burning 1 ton of fuel• By:
R September 1, 20087014-082DPage 31CB 1200 Pellet Stove 15. Soot and Fly Ash: Formation & Need for Removal in Exhaust Venting System.• Frequency
Page 327014-082DSeptember 1, 2008R CB 1200 Pellet Stove Correct Flame Size, Yellow/White in ColorCorrectFigure 32.3Ash Build Up in FireboxPellets Bac
R September 1, 20087014-082DPage 33CB 1200 Pellet Stove 2. Exhaust Blower ReplacementG. Igniter ReplacementF. Baffle Removal1. Use proper shut dow
Page 347014-082DSeptember 1, 2008R CB 1200 Pellet Stove H. Glass Replacement• Glass is 5mm thick high temperature heat-resistant ceramic glass.• D
R September 1, 20087014-082DPage 35CB 1200 Pellet Stove 11Reference Materials7. Heat ExchangersThe heat exchangers transfer hot air from the exhaust
Page 367014-082DSeptember 1, 2008R CB 1200 Pellet Stove 16. Snap Disc #1 (Convection Blower) 145°FSnap disc #1 is located on the right side of the a
R September 1, 20087014-082DPage 37CB 1200 Pellet Stove B. Component LocationsHeatOutputFanSpeedReset ButtonCall LightHIGHHIGHMEDLOWLOWPower OutletTe
Page 387014-082DSeptember 1, 2008R CB 1200 Pellet Stove Figure 38.1 - Door, Face, Glass & Door Latch AssemblyFigure 38.2 - Firepot, Igniter &
R September 1, 20087014-082DPage 39CB 1200 Pellet Stove Figure 38.12324252627282930313233343536373839404142434445464748Nbr Description23 Door Assembl
Page 47014-082DSeptember 1, 2008R CB 1200 Pellet Stove 1Listing and Code ApprovalsA. Appliance CertificationC. Glass SpecificationsE. BTU & Effic
Page 407014-082DSeptember 1, 2008R CB 1200 Pellet Stove 515253545556707172736274575859606163646566676869757677Figure 39.1Nbr Description51 Exhaust Pl
R September 1, 20087014-082DPage 41CB 1200 Pellet Stove IMPORTANT: THIS IS DATED INFORMATION. The most current information is located on the Quadra-
Page 427014-082DSeptember 1, 2008R CB 1200 Pellet Stove Grille, Bar, Bottom 410-833072 Handle, Hopper Lid 200-0110Heat Output Control Switch, (Rocker
R September 1, 20087014-082DPage 43CB 1200 Pellet Stove Appliance Part No.Classic Bay 1200 Freestanding Pellet Stove CB1200-BAccessories Part No.Bric
Page 447014-082DSeptember 1, 2008R CB 1200 Pellet Stove Date of Service Performed By Description of ServiceE. Service And Maintenance Log
R September 1, 20087014-082DPage 45CB 1200 Pellet Stove F. Homeowner’s Notes
Page 467014-082DSeptember 1, 2008R CB 1200 Pellet Stove G. Warranty PolicyHearth & Home Technologies LIMITED WARRANTYHearth & Home Technolog
R September 1, 20087014-082DPage 47CB 1200 Pellet Stove this noise are not covered by this warranty. HHT’s obligation under this warranty does not
R Hearth & Home Technologies1445 North HighwayColville, WA 99114Division of HNI INDUSTRIESwww.quadrafire.com7014-082D Septemer 1, 2008Page 48CONT
R September 1, 20087014-082DPage 5CB 1200 Pellet Stove 2Getting StartedA. Design, Installation & Location ConsiderationsB. Fire SafetyMaintain t
Page 67014-082DSeptember 1, 2008R CB 1200 Pellet Stove D. Inspect Appliance & Components and Pre-Use Check ListReciprocating SawChannel LocksHamm
R September 1, 20087014-082DPage 7CB 1200 Pellet Stove 3Dimensions and ClearancesA. Appliance Dimensions5.0 in(127mm)4-5/8 in(118mm)12-3/8 in(314mm
Page 87014-082DSeptember 1, 2008R CB 1200 Pellet Stove Straight Back Against WallInches MillimetersABack Wall to Appliance 2 51BSide Wall to Applian
R September 1, 20087014-082DPage 9CB 1200 Pellet Stove *L Exception for Horizontal Installations:USA INSTALLATIONS: A non-combustible floor protec-tio
Comments to this Manuals